• When you click on links to various merchants on this site and make a purchase, this can result in this site earning a commission. Affiliate programs and affiliations include, but are not limited to, the eBay Partner Network.

Discussion “A Better Fighting Garment…” - A Beginner’s Guide to the US Navy’s WWII-era and later Intermediate Flight Jackets

London Cabbie

Well-Known Member
4. AN6552 [1943] “ … a better fighting garment ...”?

The quote above, and in the title of this thread, is mischievously drawn from remarks within the 1943 AAF Authority mentioned by Jan.

After the aborted experiment that was the AN-6552 AN-J-3, the Navy’s AN-6552 label was a return to form, albeit with a couple of upgrades: in order to reduce reflectivity at night and thereby increase a downed pilot’s chances of escape, the AN-6552 was furnished with blackened no. 5 zippers, where nickel had previously been the norm. Much of the blackening agent would wear off after months of use, but traces of it remain on originals. Likewise, whereas most earlier Navy jackets had been stitched using cotton thread, with the AN-6552, nylon, which was stronger, became the norm. Even here, there were exceptions: Monarch continued using cotton. Both of these changes had already appeared in the few test jackets that were produced for the AN-J-3, but it was with the AN-6552 that they made their way into issued flight jackets. Third, since this was at least technically a joint service jacket, as Moore points out, the “USN” stencil used on M-422A and later G-1 jackets is replaced with a “US” stencil [in white or yellow].

The AN-6552 began production in 1943. Contracts were awarded to five companies: American Sportswear, Bogen & Tanenbaum, Monarch, Willis & Geiger, and H&L Block.” Moore notes, that “[w]hile H&L Block made a good number of M-422A jackets, it is thought that they made very few AN-6552 jackets”; thus making the H&L Block AN-6552s amongst the rarest of an already scarce group of jackets.

There is some uncertainty about the duration of contracts bearing this label. Moore states that the AN-6552 was only issued for about 6 months. During WWII, however, the fiscal year was from 1 July to 30 June and Full Gear lists the AN-6552 contracts as starting in fiscal year 1944 and ending in 1945. This would suggest that production began sometime in the second half of 1943 and ended mid-way through 1944 or even later.

This is not the only uncertainty. As noted above in relation to AN-J-3, the War Department’s authorization for a change of status of equipment in May 1943 refers to AN-6552. The Remarks on the authority refer to a Specification AN-J-3 and a drawing AN-6552. This remark has divided opinion amongst the authors of this thread and raises a point of controversy which would need much more research than is relevant to a beginners guide. We cannot be certain that this Army Air Forces document represents the BuAero position and that AN-6552 was a BuAero drawing number. It is an intriguing possibility that some of the confusion around the relationship between AN-J-3, AN-6552 and AN-J-3A might have arisen if AN-6552 was a BuAero drawing and references to a specification and a drawing number have been used interchangeably. Without further research though it’s not possible to do more than speculate.

SPECIFICATION: AN-6552Contract datesComments/ [source]
AN-6552 AMERICAN SPORTSWEAR CO. CONTRACT NO.N288s-28627
AN-6552 AMERICAN SPORTSWEAR CO. CONTRACT NO.N288s-24332
AN 6552-42 BOGEN & TENENBAUM CONTRACT NO. N 288s32281
AN 6552-40 BOGEN & TENENBAUM Contract No. N 288s24333
AN 6552-40 WILLIS AND GEIGER INC. CONTRACT -N288s28628Awarded 1/43, completed 5/43?This date is open to question bearing in mind the fiscal year detail above
AN 6552-38 WILLIS AND GEIGER INC. CONTRACT -N288s32357Awarded 5/43, completed 10/43?This date is open to question bearing in mind the fiscal year detail above
AN 6552 H.& L.BLOCK CONTRACT NO.N288s-20559
AN 6552 MONARCH MFG. CO. MILWAUKEE CONTRACT No.N288s-32358


Willis & Geiger AN 6552-38 Contract N288s32357, courtesy of @Jorgeenriqueaguilera

View attachment 71242

View attachment 71243

View attachment 71244

View attachment 71245

View attachment 71246View attachment 71247

View attachment 71248

View attachment 71249

View attachment 71250

View attachment 71251
Outstanding photos.
 

mulceber

Moderator
SUPERSEDED BY 2.0
Hi all, after a relaxing Christmas break, we're ready to continue with this project. So, without further ado...

Part 2 - After the Second World War - Post WW2, the Korean War, and the 1950s.

6. G-1 (55J14) [1947 - 1950]

The 55J14 is the first iteration of what would become the venerable Type G-1 jacket. It had a few prominent manufacturers; namely: Aviators Clothing co. (formerly the well-known AAF contractor, Aero Leather Clothing), L.W. Foster Sportswear, A.Prtizker & Sons, Star Sportswear, Burjac Sportswear (formerly known as Edmund T. Church Co., which had a small M-422A contract), and the (incredibly rare) B-G Inc. While this specification was issued for four years, the seal-brown goatskin of the 55J14 is especially prone to red-rot. As a result, fewer wearable examples of the 55J14 exist today than of the M422A, and the 55J14 may well be the rarest of all the G-1 flight jackets to be found in wearable condition.

Jackets made under the 55J14 specification tended to be shorter than previous specifications and tighter in the gut. They nonetheless retain most of the characteristics of earlier intermediate flight jackets, such as the USN stenciled under the collar. Furthermore, to quote Dave Sheeley, it appears that the 55J14s were the last series of jackets to be made of both vegetable- and chromium-tanned goatskin; the last clear use of veg-tanned goatskin (amongst chrome-tanned goatskin) appeared in the 1950 B-G Inc. contract. The B-G 55J14 is also the last model USN jacket that was constructed using both nylon and cotton thread. We therefore follow Sheeley in characterizing the 55J14 as a transitional flight jacket.

SPECIFICATION 55J14 (AER)Contract datesComments
L.W.FOSTER SPORTSWEAR CO. INC.CONTRACT NO.N-383s-96273
A. PRITZKER & SONS, INC. CONTRACT NO.N383s-69537
BURJAC SPORTSWEAR INC.CONTRACT No N383s-52991947?Manufacturer formerly known as "Edmund T. Church Co."
AVIATORS CLOTHING CO., INC. CONTRACT NO. N-383s-22111Contract issued 1949 [Sheeley]Manufacturer formerly known as "Aero Leather Clo. Co."
B.-G. INC. CONTRACT NO. 383s-259231950 [Sheeley]
STAR SPORTSWEAR MFG.CO. LYNN, MASS. CONTRACT NO. N383s-51863
STAR SPORTSWEAR MFG.CO. LYNN, MASS.CONTRACT NO. N383Ss-39943
L.W.FOSTER SPORTSWEAR CO. INC. CONTRACT NO. N383s-20445
L.W.FOSTER SPORTSWEAR CO. INC. CONTRACT NO. N383s-13120

Pritzker & Sons 55J14, courtesy of @Jorgeenriqueaguilera
308AF50E-D296-4955-99C4-0C479BDEC0E5.JPG

22AA11F4-BBC6-4AA4-A1E3-3FB1FD99B3F0.JPG

D6AE6258-5B90-42A6-9675-10AF96BE00EC.JPG

C9729F0A-73F5-4BB6-837C-DDEC33061797.JPG

CBF12E50-59FA-4783-8EF5-D6582E9C6C38.JPG

D233C082-E295-4848-8F95-C64333D7651E.JPG

FA899DCA-9EC2-4905-BE37-FC8D26BF42EE.JPG

A11F2AE1-E97C-4CC9-9638-900E0D62D404.JPG

220F68B4-2817-4A8F-86EE-4D5089E87877.JPG

8F3C67AF-D20A-47DB-A694-8C2F7679451D.JPG
 
Last edited:

B-Man2

Well-Known Member
Guys !
PLEASE! …. PLEASE! …… PLEASE! … Do what ever is necessary to turn the information in this thread into a permanent resource “Sticky” or some other type of permanent resource document. The information here is too valuable to let fade away over time into the VLJ thread archives.
Thank you all for this impressive research and photographs .
MODS …… Please make this happen .
 

Lord Flashheart

Well-Known Member
SUPERSEDED BY 2.0
Continuing the story from Jan ...


7. MIL-J-7823 (AER) [1951 - 1960] “....the specifications were defective…”


The 7823 (AER) is the first iteration of its own series of G-1 jackets, with the first contract of 1951 belonging to Monarch Mfg. Co. Despite subtle differences between different manufacturers, the 7823 (AER) series retained most of the 55J14’s hallmarks, such as the no.5 blackened Conmar zipper. Most noticeably, because the 7823 specification ran from 1951 to 1961 (a 10 year span), there were many formal and informal amendments to the specification over time. An example of an informal amendment is most easily demonstrated by the shape of the pocket flaps as between 7823 (AER)s. Imagine a 1951 Monarch Mfg. (N383s-80667), a 1957 Cagelo Sportswear (N383-39321A), and a 1958 L.W. Foster Sportswear (DA-36-243-QM(CTM)2134). Their pocket shapes range from scalloped, to triangular, to rounded (respectively). Minor evolutions like these exist throughout the 7823 (AER) specification. Although perhaps a quirk between manufacturers, it is commonly agreed that pocket flaps (as with many other features) became plainer in design for easier manufacturing as time went on. An example of a formal amendment is demonstrated with L.W. Foster Sportswear’s 7823 (AER) & AMEND #2 of the N383-22356A contract of 1955, where the amendment is clearly stated on the tagging of the jacket. Perhaps another important change of note is the shift from the USN stencil under the collar of jackets to a USN hole stamp on the wind-flap in the mid-late 50s.

An important change with ramifications for how Navy jackets were made came in 1956, when contracting for military garments passed from the Navy to a completely new agency, the Military Clothing and Textile Supply Agency (MCTSA), which served all branches of the military. While bringing under one roof all the contracting for the clothing used by the different branches made a certain amount of sense, the MCTSA lacked the experience and flexibility of the Navy. The approach of the MCTSA became a source of conflict.

The result was L. W. Foster Sportswear Co., Inc. v. the United States, a court decision handed down on January 24, 1969 https://casetext.com/case/lw-foster-sportswear-co-v-united-states-2 concerning two 1958 contracts for about 54,000 jackets.

From 1949 to 1956, L.W. Foster had successfully manufactured approximately 200,000 flying jackets for BuAer under a series of contracts which contained specifications the same as or very similar to the 1958 contracts. L.W. Foster "envisioned no difference" as to what would constitute an acceptable garment under the contracts now being given out by the MCTSA because, although a new procurement agency was involved, the contract was for same jackets which it had previously made for the Navy. At the peak of these contracts the company was delivering nearly 3000 jackets each week although they were delivered late. L.W. Foster sought an adjustment of the contract price to reimburse additional costs which was rejected by MCTSA.

L.W. Foster argued in court that the specification requirements for the type of seams for the joining of the knit to the leather and the rayon lining underneath did not accord with the best practices of the trade, were virtually impossible to perform without causing abrasions and cut leather, which would be scored as defects, and that the operation should be performed by another method. Another problem developed with regard to the method of sewing the pocket flap to the face of the jacket. The company argued that the method prescribed by the specifications was inconsistent with the contract diagram, was "practically impossible" to accomplish and could cause damage to the jacket. On top of this the quality assurance regime revealed scoring as major defects healed scars and healed briar scratches by an Inspector who did not know what these were and with mended knits scored as defects but which did not affect appearance or serviceability. These were not the only issues that led to the lawsuit.

In judgment, the six Judges held “There is no doubt, in the first place, that the specifications were defective. The record clearly reflects instances in which defendant's agents admitted as much. The Government later amended the specifications in question, incorporating many of the changes found necessary in the performance of this contract.” and found that the company knew that it could not produce an acceptable flying jacket under the contract specifications, as written, at the time that it submitted its bid. But it had had five or six previous contracts with the Navy for the same type of jacket, with the same or very similar specifications, and in every case deviations were made and allowed as a matter of course — and had to be made for production to go on. The Judges concluded that the company had acted reasonably in assuming that the formal change from BuAer to MCTSA did not break the working relationship which had already been established.

The circumstances of this lawsuit may well have played a part in the split of Lou and Irvin Foster. Whilst Lou stopped making leather jackets, Irvin nevertheless went on to deliver a number of subsequent 7823 series jackets under Irvin B.Foster & Sons Sportswear Co. We speculate that Irvin may have worked with the Navy to revise the specification and make the design commercially practical. As the government amended the jacket specification after 1960, this would have made the construction more predictable for everyone albeit, from our perspective on VLJ, probably less interesting and varied in detailing. As we'll see from this point forward, the different G-1 contracts become much more uniform in their design and are quite difficult to distinguish without a spec label.
 
Last edited by a moderator:

Lord Flashheart

Well-Known Member
SPECIFICATION MIL-J-7823(AER)Contract datesComments
MONARCH MFG. CO. CONTRACT NO. N383s-806671951 [Sheeley] / 1952 [roughwear VLJ]?
WERBER SPORTSWEAR, INC. CONTRACT NO.383S-888861952?
A. PRITZKER & SONS, INC.CONTRACT NO. N383S-319A1953 Was omitted on the earlier list [roughwearVLJ]
RALPH EDWARDS SPORTSWEAR CONTRACT NO. QM.(CTM)-2313
L.W.FOSTER SPORTSWEAR CO., INC CONTRACT NO.N383s-74471
SPECIFICATION MIL-J-7823(AER) & AMEND. #2 L.W. FOSTER SPORTSWEAR CO, INC. CONTRACT N383-22356A1955 [deeb7 VLJ]
J.A.DUBOW SPORTING GOODS CORP. CONTRACT NO. N383S-4765A
J.A.DUBOW SPORTING GOODS CORP. CONTRACT NO. N383S-4833A
CAGLECO SPORTSWEAR CONTRACT NO N383s-9211A1954 [Sheeley]https://www.vintageleatherjackets.org/threads/duplicated-fathers-original-g-1-flight-jacket.20658/
CAGLECO SPORTSWEAR CONTRACT NO N383s-14722A
CAGLECO SPORTSWEAR CONTRACT NO N383-28657A
CAGLECO SPORTSWEAR CONTRACT NO N383-39321A1957 [ roughwear VLJ]https://www.vintageleatherjackets.o...cket-mil-j-7823-aer-helantisubron-five.26740/

https://www.vintageleatherjackets.o...ermediate-flight-jacket-mil-j-7823-aer.26351/
CAGLECO SPORTSWEAR CONT QM(CTM)-144-O.I.-2515-E-571957
L.W. FOSTER SPORTSWEAR CO., INC. CONTRACT
NO.DA-36-243-QM(CTM)2312
Contract date 29th April 1958, delivered in 1958

See L. W. Foster Sportswear Co., Inc. v. the United States. January 24, 1969 :
Delivery at peak of nearly 3000 jackets per week.
L.W.FOSTER SPORTSWEAR CO., INC CONTRACT NO. DA-36-243-QM(CTM)2134Contract date four weeks after QM(CTM)2312 1958, delivered in 1959

See L. W. Foster Sportswear Co., Inc. v. the United States. January 24, 1969:
Delivery at peak of nearly 3000 jackets per week.

https://www.vintageleatherjackets.o...e-flight-jacket-mil-j-7823-aer-vma-223.27125/
CALIFORNIA SPORTSWEAR COMPANY CONTRACT #QM(CTM)4771-E-601960https://www.vintageleatherjackets.org/threads/original-california-sportwear-g-1.25300/
BREIER OF AMSTERDAM, INC. QM(CTM)6837-C-601960
 
Last edited by a moderator:

Chandler

Well-Known Member
So I asked @Lord Flashheart if there was a need for some images of the Monarch contract of the 7823 and he said, "Of course." so here are a few snaps of mine. I think I can dig up some better, studio pics of this one if I ask politely, but I'll start with these.

Of interest to this particular jacket is that there's no Navy identifier anywhere; no stencil on the collar at all. It also has that telltale "hooked" hanging loop, so I have to wonder if this one served as a "community" jacket and hung in the ready room a long time.

Also, has anyone provided details of Coast Guard jackets? I thought I remembered hearing they were provided with G-1s -- maybe that explains no Navy I.D. on this one?

Anyway, as promised.
yJTtecS.jpg

q2dyRwg.jpg

QW5BbLL.jpg
 

Lord Flashheart

Well-Known Member
Thank you Chandler and Entertainment for adding those examples to this thread. The Coastguard question isn’t one we’d come across so it’d be interesting to hear from anyone who might know about their jackets. Certainly seems possible that the USN marking wouldn’t be present and perhaps shows another small twist on a contract perhaps?

You‘re not going to mistake that Breier with that liner either!
 
Last edited:
Top